High Mileage Club (>150000km)
Rules: there is only one rule, you may only comment if your car has more that 150000Km on the clock
I'll start:
What model & year is your IO? 2000 Straight up IO
How much mileage had your IO done? 177352 Km
Engine size? 1.6
Engin code? 4G18
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
- Timing belt
- Clutch
- Front steering rack
bob io
What model & year is your IO? 2002 ZR IO
How much mileage had your IO done?
2009 115000 Km when bought, in 2009
march 2012 165,000kms
November 2013 220,000
Engine size? 2.0
Engin code? 4G94
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
- Timing belt at 100,000kms
- Timing belt at 200,000kms (see DIY section)
- New front struts and rear shocks at 200,000kms
nothing else - all good!
2014 update:
1.925 gears in transfer case
rear lower front suspension arm bushes
front diff bush
engine mounts and transfer mounts - all appeared to go soft around 225,000kms at once
rocker cover gasket, spark plug gaskets, irridium plugs
I ran an upper cylinder cleaner through at 230,000kms and it made it like it was back when I bought it! - laying black smoking lines now!!!
What model & year is your IO?
What model & year is your IO? 1999 5dr
How much mileage had your IO done? 245 000 Km
Engine size? 1.8
Engin code? wouldnt have a clue
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
I haven't done any work to the car myself - but when I purchased it I was advised a top end rebuild of the engine was done because it was cooked basically. All of the cooling devices (fans, radiator, etc..) were replaced
Finally a member!
What model & year is your IO? 2001 QA
How much mileage had your IO done? 150200
Engine size? 1.6
Engin code? 4G18
Is it the original motor? Yes, who would put a 1.6 back in.
Any major work done (Motor, transfer case, gear box ect)? Nill. Cant wait for the motor to die so I can get a 2.0.
What model & year is your IO?
What model & year is your IO? 2001 QA SWB Manual purchased with 118,000km in nov 2010
How much mileage had your IO done? 150,090 km - made it into the club today
Engine size? 2.0l
Engine code? 4G94
Is it the original motor? Yep
Any major work done (Motor, transfer case, gear box ect)? Timing belt had been replaced at 110,000km. Rear Main seal replaced at 125,000km, heavy duty clutch installed at the same time.
What model & year is your IO?
What model & year is your IO? 4 door lwb iO,1999
How much mileage had your IO done? 167,947km
Engine size? 1.8
Engin code? 4G93
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
- Timing belt
- Front steering rack
- Raised suspension
Worldomin8's iO
What model & year is your IO? 99 Pajero iO 3dr
How much mileage had your IO done? 200 656 km's
Engine size? 1.6 litre
Engin code? 4G18
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
No major work done just yet. About to replace timing belt as per 200,000 service.
314,142kms....
Nov 2000 build, 5 door
314,142 kms.....
4G93 1.8L
Original motor yes. All original drivetrain, brakes, etc. Major service againat 300,000. As well as water pump, cam belt etc, replaced coilpacks, iridium plugs and leads. On car fuel system service. New fuel pump. K&N filter. New pads. Run like a rocket again! A slow rocket, but still.... :)
my car
What model & year is your IO? 2004 Pinin AT 5d
How much mileage had your IO done? 203000 Km
Engine size? 2.0
Engin code? 4G94
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
- Shock absorber (front and rear axis)
- Silencer (all parts, except catalyst)
- Timing belt (but this is reglament operation)
What model & year is your
What model & year is your IO? 2003 Straight up IO
How much mileage had your IO done? 260+ Km
Engine size? 2.0
Engin code? 4G94
Is it the original motor? No
Any major work done (Motor, transfer case, gear box ect)?
New engine from donor lancer before i bought it. Had 26000km on it in 2007
Guessing this donk has more than 150000km on it now too. Runs like clockwork and taken a hammering.
Dont know what happened to the original motor to be taken out.
Fuel filter changed when i got the car, along with all other filters that all looked very ordinary.
considering transmission service although works fine
346,809kms.... :)
As of today, ive covered 346,809kms :)
Few whines and moans now, but still running, strong. The 1.8 oes through a wee bit of oil too, but never mind...
Feeling a bit worn now, but not sure if ill ever get rid of it :)
Grown quite attached over the years :)
Just stuck a nee clutch in recently. Iridium plugs, coil packs, coolant done every 100,000. Oil every 10. Look after best i can, but not afraid to trear her ruff :)
whining
nice work -
i've got a bit of a whine now at just-off-power, sounds like rear diff but could also be transfer box - more like a dull "singing" peaking at around 65km/h. only comes on after 15mins driving once the oil warms up.
I'm also running hotter in my transfer as there is minimal clearance between gear and case resulting in throwing more oil around
What model & year is your IO?
What model & year is your IO? 2002 3dr Pajero iO ZR
How much mileage had your IO done? 177681 Km
Engine size? 2.0
Engin code? 4G94
Is it the original motor? Yes
Any major work done (Motor, transfer case, gear box ect)?
None...
now i havent ravelled all of these kms, not even a fraction, ive only done about 6000kms in it
CHECK OUT MY BUILD VVV
http://www.pajerio.com/forum/daniels-io